Chevrolet Sonic Repair Manual: Air Inlet Grille Panel Replacement

Chevrolet Sonic Repair Manual / Body / Body Exterior / Front Grille / Air Inlet Grille Panel Replacement

Air Inlet Grille Panel Replacement
Callout	Component Name
Preliminary Procedure Remove both wiper arm assemblies. Refer to Windshield Wiper Arm Replacement. Remove both outer hood rear seals. Refer to Hood Rear Seal Replacement.
1	Air Inlet Grille Panel Retainer (Qty:?€‰4) Procedure Release and remove the retainers from the air inlet grille panel.
2	Air Inlet Panel Screw Caution: Refer to Fastener Caution. Procedure Remove the screw cover from the air inlet grille panel. Remove the air inlet grille panel screw. Tighten 2.5?€‰Y (22?€‰lb?€‰in)
3	Air Inlet Grille Panel Procedure Lift the front edge of the grille panel off the front edge of the dash upper extension panel opening cover. Slide the grille panel forward from both hood hinges. Remove the grille panel from the vehicle. Remove the hood rear weather-strip. Refer to Hood Rear Weatherstrip Replacement.

Front Grille

...

Front Lower Grille Replacement

Front Lower Grille Replacement Callout Component Name Preliminary Procedures Remove the front bumper fascia assembly. Refer to Fron ...

Other materials:

Transmission
Automatic Transmission Manual Mode This position allows you to change gears similar to a manual transmission. To use this feature: 1. Move the shift lever from D (Drive) rearward to M(Manual Mode). 2. Press the + (plus) end of the button on the side of the shift lever to upshift, or push t ...

Water Inlet Replacement (LUW)
Removal Procedure Drain the engine coolant system. Refer to Cooling System Draining and Filling. Disconnect the engine coolant temperature sensor connector (1). Remove the radiator outlet hose connector clip (2) and the radiator outlet hose ...

Engine Coolant Fan Shroud Replacement (LDE LUW)
Engine Coolant Fan Shroud Replacement Callout Component Name Preliminary Procedure Remove the radiator surge tank. Refer to Radiator Surge Tank Replacement. Unclip transmission cooler lines from shroud if equipped. Un ...

0.0045