Chevrolet Sonic Repair Manual: Brake Fluid Warning

Warning:

Use only Delco Supreme 11, GM P/N 12377967 (Canadian P/N 992667), or equivalent DOT 3 brake fluid from a clean, sealed container. Do not use fluid from an open container that may be contaminated with water. Improper or contaminated fluid could result in damage to components, or loss of braking, with possible injury.

Brake Fluid Level Indicator Switch Replacement

Removal Procedure Disconnect the brake fluid level indicator switch electrical connector. Using a small, flat-bladed tool, lift the locking tab on the underside of the brak ...

Brake Pipe Replacement

Special Tools CH-45405 Brake Pipe Flaring Kit For equivalent regional tools, refer to Special Tools. Warning: Refer to Brake Fluid Irritant Warning. Warning: Always use do ...

Other materials:

Rear Wheel Bearing and Hub Replacement (Disc Brake)
Special Tools EN–45059 Angle Meter For equivalent regional tools, refer to Special Tools. Removal Procedure Raise and suitably support the vehicle. Refer to Lifting and Jacking the Vehicle. Remove the tire and wheel assembly. Refer to Tire and Wheel Removal and Insta ...

Electronic Brake Control Module Programming and Setup
Note: DO NOT program a control module unless directed to by a service procedure or a service bulletin. If the ECU is not properly configured with the correct calibration software, the ECU will not control all of the vehicle features properly. Ensure the programming tool is ...

Manual Transmission Shift Lever and Selector Lever Cable Adjustment
Remove the floor console. Refer to Front Floor Console Replacement. Lift upward and disengage (do not remove) both cable lock adjusters (1) to release the internal cable assembly, one for each side. Block the shift control housing, push the selector lever ( ...