Chevrolet Sonic Repair Manual: Drive and Driven Sprocket, Drive Link, and Park Pawl Installation (6T40/45/50)

Chevrolet Sonic Repair Manual / Powertrain / Transmission/Transaxle / Automatic / General / Drive and Driven Sprocket, Drive Link, and Park Pawl Installation (6T40/45/50)

Drive and Driven Sprocket, Drive Link, and Park Pawl Installation
Callout	Component Name
1	Front Differential Carrier Baffle
2	Front Differential Carrier Baffle Bolt M6 x 16 (Qty: 2) Caution: Refer to Fastener Caution. Tighten 12 Y (106 lb in)
3	Drive Link Lube Scoop Seal
4	Drive Link Lube Fluid Seal
5	Drive Link Lube Scoop
6	Driven Sprocket Bearing Assembly
7	Drive Sprocket Bearing Assembly
8	Driven Sprocket Assembly, Drive Sprocket Assembly and Drive Link Note: Install the drive link with the colored links and/or part number facing up. The drive link, drive, and driven sprocket assemblies must be installed at the same time. The ball bearing should spin freely and smoothly. The driven sprocket ball bearing inner race has a slight interference fit with the case. Tap gently with the palm of a hand or a soft tip hammer to install.
9	Park Pawl
10	Park Pawl Spring
11	Park Pawl Shaft Note: Check to ensure that the park pawl operates freely and is not binding.

Drive and Driven Sprocket, Drive Link, and Park Pawl Installation (6T30)

Drive and Driven Sprocket, Drive Link, and Park Pawl Installation Callout Component Name 1 Front Differential Carrier Ba ...

Drive and Driven Sprocket, Drive Link, and Park Pawl Removal (6T30)

Drive and Driven Sprocket, Drive Link, and Park Pawl Removal Callout Component Name 1 Drive Link Lube Scoop ...

Other materials:

Exhaust Heat Shield Replacement
Exhaust Heat Shield Replacement Callout Component Name Preliminary Procedure Disconnect the exhaust system hangers and allow the exhaust system to rest on the rear axle. 1 Exhaust Heat Shield Fa ...

Fuel Pressure Relief
Special Tools EN-34730-91 Pressure Tester For equivalent regional tools, refer to Special Tools. Warning: Gasoline or gasoline vapors are highly flammable. A fire could occur if an ignition source is present. Never drain or store gasoline or diesel fuel in an open container, due ...

Fluid Passages (Gen 2)
Figure 1: Torque Converter and Differential Housing - Case Side Figure 2: Fluid Pump Body - Fluid Pump Cover Side Figure 3: Fluid Pump Cover - Fluid Pump Body Side Figure 4: Case - Torque Converter and Differential Housing Side Fig ...

0.0083