Chevrolet Sonic Repair Manual: Drivetrain and Front Suspension Frame Skid Plate Replacement
- Removal Procedure
-
- Raise and support the vehicle. Refer to Lifting and Jacking the Vehicle.
- Remove the mounting bolts?€‰(1) for the front suspension frame skid plate.
- Remove the front suspension frame skid plate?€‰(2).
- Installation Procedure
-
- Position the front suspension frame skid plate?€‰(2) on the frame.
- Install the front suspension frame skid plate mounting bolts?€‰(2) and
tighten to 22?€‰Y (16?€‰lb?€‰ft)
.
Caution:
Refer to Fastener Caution.
Center Pillar Reinforcement Replacement
Removal Procedure
Warning: Refer to Approved Equipment for Collision Repair
Warning.
Warning: Refer to Glass and Sheet Metal Handling Warning.
Note ...
Glass & Windows
...
Other materials:
When to Add Engine Oil
1.8L Shown, 1.4L Similar
If the oil is below the minimum mark on the dipstick, add 1 L (1 qt) of the recommended
oil and then recheck the level. See “Selecting the Right Engine Oil” in this section
for an explanation of what kind of oil to use. For engine oil crankcase capacity,
see Cap ...
Fuel Tank Fuel Pump Module Replacement
Special Tools
EN-48279 Fuel Sender Lock Ring Tool
For equivalent regional tools, refer Special Tools.
Removal Procedure
Relieve the fuel system pressure. Refer to
Fuel Pressure Relief
Remove the fuel tank. Refer to
Fuel Tank Replacement.
Disconnect the elect ...
Engine Replacement (Automatic Transmission)
Special Tools
J-45859 Wheel Drive Shaft Remover
CH-807 Closure Plugs
For equivalent regional tools, refer to Special Tools.
Removal Procedure
Remove the battery and battery tray. Refer to
Battery Tray Replacement.
Relieve the fuel system pressure. Refer to
Fuel Pre ...
0.0047