Chevrolet Sonic Repair Manual: Front Side Door Adjustment

Chevrolet Sonic Repair Manual / Body / Body Exterior / Panels / Front Side Door Adjustment

Front Side Door Adjustment
Callout	Component Name
Preliminary Procedure Remove the front wheelhouse liner. Refer to Front Wheelhouse Liner Replacement.
1	Front Side Door Caution: Refer to Fastener Caution. Procedure Loosen the front side door hinge bolt?€‰(Qty:?€‰4) to adjust the front side door. Adjust the front side door in order to obtain an even gap between the front side door and the roof, the rear door, the rocker panel and the front fender and so that the front side door is flush with the roof, the rear door, the rocker panel and the front fender. Adjustment Front side door to roof (a) 4.0?€‰mm ?± 1.0?€‰mm (0.16?€‰in ?± 0.04?€‰in) Front side door to rear door (above belt) (b) 3.5?€‰mm ?± 1.0?€‰mm (0.14?€‰in ?± 0.04?€‰in) Front side door to rear door (below belt) (c) 3.5?€‰mm ?± 0.75?€‰mm (0.14?€‰in ?± 0.03?€‰in) Front side door to rocker panel (d) 5.5?€‰mm ?± 1.0?€‰mm (0.22?€‰in ?± 0.04?€‰in) Front side door to fender (e) 3.5?€‰mm ?± 0.75?€‰mm (0.14?€‰in ?± 0.03?€‰in) Tighten 25?€‰Y (19?€‰lb?€‰ft)

Front Opening Upper Cover Replacement

Front Opening Upper Cover Replacement Callout Component Name 1 Radiator Opening Upper Cover Screw (Qty:?€‰10) ...

Front Side Door Check Link Replacement

iii! Front Side Door Check Link Replacement Callout Component Name Preliminary Procedure Remove the front side door trim panel. ...

Other materials:

Removing the Flat Tire and Installing the Spare Tire
1. Do a safety check before proceeding. See If a Tire Goes Flat. 2. Remove the wheel cover, if the vehicle has one, to reach the wheel bolts. 3. Turn the wheel nuts counterclockwise to loosen them. Do not remove them yet. 4. Place the jack at the position marked with a half circle. 5. In ...

Seat Belt System Description and Operation
Restraint System Note: If the vehicle has been in a collision, refer to Repairs and Inspections Required After a Collision. The vehicle has front and rear seat belts that are the primary means of occupant restraint. Seat belts help to keep the occupants inside the passenger ...

Parking Brake Cable Replacement (Drum Brake)
Removal Procedure Remove the front floor console. Refer to Front Floor Console Replacement. Ensure that the parking brake lever is in the fully released position. Using ONLY HAND TOOLS, remove the adjusting nut (1) from the end of the front park bra ...

0.0048