Chevrolet Sonic manuals

Chevrolet Sonic Repair Manual: Front Side Door Replacement

Chevrolet Sonic Repair Manual / Body / Body Exterior / Panels / Front Side Door Replacement



Front Side Door Replacement

Callout

Component Name

Warning:

Refer to SIR Warning.

Preliminary Procedures

  1. Mark the location of the hinge before removing the bolts with a grease pencil.
  2. Remove the front door trim panel. Refer to Front Side Door Trim Replacement.

1

Front Side Door Check Link Bolt to Body

Caution:

Refer to Fastener Caution.

Procedure

  1. Remove the water deflector.
  2. Disconnect the door electrical connector.
  3. Support the door before removing the hinge bolts.
  4. With an assistant, remove the door.
  5. After the door has been removed, ensure that the dome lamp is off. If the dome lamp is on remove the fuse.
Tighten


22?€‰Y (16?€‰lb?€‰ft)

2

Front Side Door Lower Hinge Bolt to Door (Qty:?€‰2)

Tighten


25?€‰Y (18?€‰lb?€‰ft)

3

Front Side Door Upper Hinge Bolt to Door (Qty:?€‰2)

Tighten


25?€‰Y (18?€‰lb?€‰ft)

4

Front Side Door Assembly

Procedure

  1. When replacing the door it is necessary to transfer all of the internal components.
  2. If the door striker needs adjust. Refer to Front Side Door Lock Striker Adjustment.
  3. Front door adjustment. Refer to Front Side Door Adjustment.
Front Side Door Check Link Replacement
iii! Front Side Door Check Link Replacement Callout Component Name Preliminary Procedure Remove the front side door trim panel. ...

Front Side Door Upper Hinge and Lower Hinge Replacement
Front Side Door Upper Hinge and Lower Hinge Replacement Callout Component Name 1 Front Side Door Upper Hinge to Body Bol ...

Other materials:

Detecting the Vehicle Ahead
The green vehicle ahead indicator will appear when a vehicle is detected ahead. Whenever this indicator does not appear, FCA will not respond. The indicator may disappear on curves, highway exit ramps, or hills, or due to poor visibility. The FCA system will not detect another vehicle ahead ...

Headlamps, Front Turn Signal and Parking Lamps
Passenger Side Shown, Driver Side Similar High-Beam Headlamp Low-Beam Headlamp Parking/Turn Signal Lamps High-Beam Headlamp/Low-Beam Headlamp Open the hood. See Hood. For the driver side bulb, remove the windshield washer bottle filler neck by turning it one-quarter ...

Airbag Front Passenger Presence Sensor Replacement
Airbag Front Passenger Presence Sensor Replacement Callout Component Name Warning: Replace the passenger presence system as a complete assembly to prevent possible injury to the occupant. All the components in the se ...

© 2014-2025 Copyright www.csmans.com
 
0.0067