Chevrolet Sonic Repair Manual: Headlining Trim Panel Replacement (Sedan without Sunroof)

Chevrolet Sonic Repair Manual / Body / Body Interior / Headlining / Headlining Trim Panel Replacement (Sedan without Sunroof)

Headlining Trim Panel Replacement
Callout	Component Name
Warning: Do not attempt to repair or alter the head impact energy-absorbing material glued to the headliner or to the garnish trims. If the material is damaged, replace the headliner and/or the garnish trim. Failure to do so could result in personal injury. Caution: If a vehicle is equipped with a head curtain inflator module ensure that the inflator module and tether are undamaged. If tether or curtain airbag are damaged in any way, they must be replaced. Caution: Use care when working around the head curtain inflator module. Sharp tools may puncture the curtain airbag. If the head curtain inflator module is damaged in any way, it must be replaced. Preliminary Procedures Disable the SIR system. Refer to SIR Disabling and Enabling. Remove the sunshade. Refer to Sunshade Replacement. Remove the sunshade support. Refer to Sunshade Support Replacement. Remove the roof rail front assist handle. Refer to Roof Rail Front Assist Handle Replacement. Remove the roof rail rear assist handle. Refer to Roof Rail Rear Assist Handle Replacement. Remove the dome lamp bezel. Refer to Dome Lamp Bezel Replacement. Remove the windshield header courtesy lamp. Refer to Windshield Header Courtesy Lamp Replacement. Remove the windshield side garnish molding. Refer to Windshield Side Garnish Molding Replacement. Remove the body lock pillar upper trim panel. Refer to Body Lock Pillar Upper Trim Panel Replacement. Remove the center pillar upper trim panel. Refer to Center Pillar Upper Trim Panel Replacement. Move the front seat fully forward and recline.
1	Headliner Trim Panel Retainer?€‰(Qty:?€‰5)
2	Headliner Trim Panel Assembly Procedure Disconnect the electrical connectors. Note: When installing a new headliner, tape any unused connector to the headliner with a high adhesive tape.

Headlining Trim Panel Replacement (Sedan with Sunroof)

Headlining Trim Panel Replacement Callout Component Name Warning: Do not attempt to repair or alter the head impact energ ...

Windshield Header Courtesy Lamp Replacement

=i_ii.========= Windshield Header Courtesy Lamp Replacement Callout Component Name 1 Windshield Header Courtesy Lamp P ...

Other materials:

Differential Carrier Removal (6T30)
Differential Carrier Removal Callout Component Name 1 Differential Carrier Assembly 2 Final Drive Sun Gear ...

Engine Oil Cooler Coolant Inlet Hose Replacement (LUV)
Engine Oil Cooler Coolant Inlet Hose Replacement Callout Component Name Preliminary Procedure Open the hood. Drain the cooling system. Refer to Cooling System Draining and Filling. 1 Oil Coo ...

Valve Stem Oil Seal and Valve Spring Replacement
Special Tools 207649 Rod Hairpin Clips 547324 Flange Screws EN-840 Pliers / Remover EN-958 Installer EN-45059 Angle Meter EN-50717 Kit J-43649?E Rods For equivalent regional tools, refer to Special Tools. Removal Procedure Remove the spark plugs. Refer to Spark ...

0.0057