Chevrolet Sonic Repair Manual: Intake Manifold
- Intake Manifold Assemble
- Intake Manifold Assemble (1.6L LDE)
- Intake Manifold Assemble (1.8L LUW and LWE)
- Intake Manifold Cleaning and Inspection
- Intake Manifold Disassemble
- Intake Manifold Disassemble (1.6L LDE)
- Intake Manifold Disassemble (1.8L LUW and LWE)
- Intake Manifold Installation
- Intake Manifold Installation (1.6L LDE)
- Intake Manifold Installation (1.8L LUW and LWE)
- Intake Manifold Removal
- Intake Manifold Removal (1.6L LDE)
- Intake Manifold Removal (1.8L LUW and LWE)
- Intake Manifold Replacement
- Intake Manifold Replacement (LDE)
- Intake Manifold Replacement (LUW)
- Intake Manifold Tuning Valve Actuator Replacement
Charge Air Cooler Replacement
Charge Air Cooler Replacement
Callout
Component Name
Preliminary Procedures
Disconnect the negative battery cable. Refer to Battery ...
Intake Manifold Assemble
Install the evaporative emission canister purge solenoid valve (3).
Install the 2 manifold absolute pressure sensors (2).
Install the 2 manifold absolute pressur ...
Other materials:
Fog Lamp Aiming
Preparation Procedure
Note: Horizontal aim is not adjustable on this vehicle. Vertical
aim is done by an adjusting nut located on the rear of the fog lamp. Prior
to aiming the fog lamps, perform the following steps:
Completely assemble all of the components on the vehi ...
Battery Charging
Special Tools
EL 50313 Battery Tester
For equivalent regional tools, refer to Special Tools.
Diagnostic Aids
For best results, use an automatic taper-rate battery charger with a
voltage capability of 16 V.
The charging area should be well ventilated.
Do not charge a bat ...
Clutch Master Cylinder Replacement
Removal Procedure
Remove the battery tray. Refer to
Battery Tray Replacement.
Remove as much brake fluid out of brake fluid reservoir
as possible.
Remove the clutch master cylinder reservoir hose (1)
from the clutch master cylinder.
Unclip th ...
0.0084