Chevrolet Sonic Repair Manual: Low and Reverse and 1-2-3-4 Clutch Housing Cleaning and Inspection

Chevrolet Sonic Repair Manual / Powertrain / Transmission/Transaxle / Transmission Oil Cooler / Transmission Unit / Low and Reverse and 1-2-3-4 Clutch Housing Cleaning and Inspection

Low and Reverse and 1-2-3-4 Clutch Housing Cleaning and Inspection
Callout	Component Name
Caution: After cleaning the transmission components, allow to air dry. Do not use cloth or paper towels in order to dry any transmission components. Lint from the towels can cause component failure. Caution: Do not reuse cleaning solvents. Previously used solvents may deposit sediment which may damage the component. Preliminary Procedures Thoroughly clean the housing with clean solvent. Inspect the piston bores and retainer ring grooves for wear, damage or porosity.
1	1??? Clutch Spring Retainer Groove
2	1??? Clutch Piston Bore
3	Low and Reverse Clutch Spring Retainer Groove
4	Low and Reverse Clutch Piston Bore
5	Clutch Oil Passages
6	Air Bleed Passages

Low and Reverse and 1-2-3-4 Clutch Housing Assemble (6T40/45/50)

Table 1: 1??? Clutch Piston Installation Table 2: Low and Reverse Clutch Piston Installation 1??? Clutch Piston Installation 1??? Clutch Piston Installa ...

Low and Reverse and 1-2-3-4 Clutch Housing Disassemble

Table 1: Low and Reverse Clutch Piston Removal Table 2: 1??? Clutch Piston Removal Low and Reverse Clutch Piston Removal Low and Reverse Clutch Piston R ...

Other materials:

Heated Front Seats
Warning If you cannot feel temperature change or pain to the skin, the seat heater may cause burns. To reduce the risk of burns, people with such a condition should use care when using the seat heater, especially for long periods of time. Do not place anything on the seat that insulates again ...

Tire Rotation and Required Services Every 12 000 km/ 7,500 mi
Rotate the tires, if recommended for the vehicle, and perform the following services. See Tire Rotation. Check engine oil level and oil life percentage. If needed, change engine oil and filter, and reset oil life system. See Engine Oil and Engine Oil Life System. Check engine coo ...

Passenger Compartment Air Filter Replacement (LHD)
Passenger Compartment Air Filter Replacement Callout Component Name Preliminary Procedure Remove IP compartment. Refer to Instrument Panel Lower Compartment Replacement. 1 Passenger Compartment A ...

0.0062