Chevrolet Sonic Repair Manual: SIR Seatbelt Pretensioner Handling Warning

Warning:

When carrying an undeployed inflatable restraint seat belt retractor pretensioner:

• Do not carry the seat belt pretensioner by the seat belt webbing or pigtail connector, if equipped.
• Carry the seat belt pretensioner by the housing, keeping hands and fingers away from the seat belt webbing.
• Make sure the opening, from which the seat belt webbing extends, faces downward and the seat belt webbing hangs freely.

Failure to observe these guidelines may result in personal injury.

SIR Inflator Module Handling and Storage Warning

Warning: When carrying an undeployed inflator module: Do not carry the inflator module by the wires or connector. Make sure the air bag opening points away from you. When storing an u ...

SIR Service Precautions

General Service Instructions Warning: When performing service on or near the SIR components or the SIR wiring, the SIR system must be disabled. Refer to SIR Disabling and Enabling ...

Other materials:

Hood Primary Latch Release Cable Replacement
iv Hood Primary Latch Release Cable Replacement Callout Component Name Preliminary Procedures Remove the radiator opening upper cover. Refer to Front Opening Upper Cover Replacement. Remove the air inlet grille. Refer to A ...

Rear Seat Back Cushion Hinge Replacement
Rear Seat Back Cushion Hinge Replacement Callout Component Name Preliminary Procedure Remove the rear seat cushion. Refer to Rear Seat Cushion Removal and Installation Remove the rear seat back cushion. Refer to Rear Seat ...

Front Disc Brake Pads Replacement
Removal Procedure Warning: Refer to Brake Dust Warning. Note: Always replace disc brake pads in axle sets. Inspect the fluid level in the brake master cylinder reservoir. If the brake fluid level is midway between the maximum-full point and the minimum allowab ...