Chevrolet Sonic Repair Manual: Sunroof Module Assembly Replacement

Chevrolet Sonic Repair Manual / Body / Roof - Fixed, Leisure / Moonroof/Sunroof / Sunroof Module Assembly Replacement

Sunroof Module Assembly Replacement
Callout	Component Name
Preliminary Procedures Remove the sunroof window. Refer to Sunroof Window Replacement. Remove the headliner. Refer to Headlining Trim Panel Replacement. Disconnect the front and rear sunroof drain hoses. Refer to Sunroof Housing Front Drain Hose Replacement and Sunroof Housing Rear Drain Hose Replacement.
1	Sunroof Module Bolts (Qty?€‰:9) Caution: Refer to Fastener Caution. Procedure With an assistant, lower and remove the sunroof module assembly from the vehicle. Place the sunroof assembly on a clean dry surface. Transfer all necessary components to the new module assembly. Tighten 9?€‰Y (80?€‰lb?€‰in)
2	Sunroof Module Procedure Secure the harness to the sunroof module. Adjust the sunroof window. Refer to Sunroof Window Height and Opening Fit Adjustment. Verify the proper operation of the sunroof before securing the headliner. Ensure the motor/actuator initialization/teach process has been done. Refer to Sunroof Motor/Actuator Initialization/Teach Process.

Sunroof Housing Rear Drain Hose Replacement

Sunroof Housing Rear Drain Hose Replacement Callout Component Name Preliminary Procedures It is only necessary to lower the headlin ...

Sunroof Window Height and Opening Fit Adjustment

Note: Correct adjustment cannot be achieved if the sunroof window is closed from vent position. Cycle the sunroof window from full open to closed position. ., Note: Do Not re ...

Other materials:

Door Lock Switch Replacement
Door Lock Switch Replacement Callout Component Name Preliminary Procedure Remove the heater and air conditioning control. Refer to Heater and Air Conditioning Control Replacement. 1 Door Lock Sw ...

Rear Compartment Lid Inner Panel Trim Replacement (Sedan)
Rear Compartment Lid Inner Panel Trim Replacement Callout Component Name Preliminary Procedures Remove the rear compartment lid outer bumpers. Remove the latch cover. 1 Rear Compartment Lid Inner ...

Drive Range, Fifth Gear (Gen 2)
As vehicle speed increases, the transmission control module (TCM) processes input signals from the automatic transmission input and output speed sensors, the throttle position sensor and other vehicle sensors to determine the precise moment to command ON the normally-low 35R pressure control s ...

0.0056