Chevrolet Sonic Repair Manual: Sunroof Window Height and Opening Fit Adjustment

Chevrolet Sonic Repair Manual / Body / Roof - Fixed, Leisure / Moonroof/Sunroof / Sunroof Window Height and Opening Fit Adjustment

Note:

Correct adjustment cannot be achieved if the sunroof window is closed from vent position.

Cycle the sunroof window from full open to closed position.

Note:

Do Not remove or lower headliner to access sunroof window screws.

Loosen the adjusting screws on the window.
Adjust the corners of the front window panel using the following guidelines:

Adjust the front of the sunroof window to?€‰0.0?€‰mm?€‰??’?€‰1.0?€‰mm (0.0?€‰in?€‰??’?€‰0.04?€‰in?€‰) below the top surface of the roof panel.
Adjust the rear center line of the sunroof window to?€‰2?€‰mm?€‰ to ?€‰3?€‰mm (0 .08?€‰in?€‰ to?€‰0.12?€‰in?€‰) below the top surface of the roof panel.

Caution:

Refer to Fastener Caution.

Tighten the sunroof window adjustment screws to 5?€‰Y (44?€‰lb?€‰in)

Cycle sunroof window through all positions.

Inspect the sunroof window adjustment. Adjust if necessary.

Sunroof Module Assembly Replacement

Sunroof Module Assembly Replacement Callout Component Name Preliminary Procedures Remove the sunroof window. Refer to Sunroof Windo ...

Sunroof Window Replacement

Sunroof Window Replacement Callout Component Name 1 Sunroof Window Bolt?€‰(Qty:?€‰4) Caution: Refer to F ...

Other materials:

Front Floor Console Cup Holder Replacement
Front Floor Console Cup Holder Replacement Callout Component Name Preliminary Procedure Remove the front floor console assembly. Refer to Front Floor Console Replacement. 1 Front Floor Console C ...

Engine Coolant Fan Replacement (LUV)
Engine Coolant Fan Replacement Callout Component Name Preliminary Procedure Remove the engine coolant fan shroud. Refer to Engine Coolant Fan Shroud Replacement. 1 Engine Coolant Fan Motor Elect ...

Ignition and Start Switch Housing Replacement
Ignition and Start Switch Housing Replacement Callout Component Name Preliminary Procedures Remove the theft deterrent module. Refer to Theft Deterrent Module Replacement. Remove the turn signal switch bracket. Refer to T ...

0.0048