Chevrolet Sonic manuals

Chevrolet Sonic Repair Manual: Thrust Washer and Bearing Cleaning and Inspection

Chevrolet Sonic Repair Manual / Body / Wipers, Washers / Washer Fluid System / Thrust Washer and Bearing Cleaning and Inspection



    Warning:

    Wear safety glasses to avoid injury when using compressed air or any cleaning solvent. Bodily injury may occur if fumes are inhaled or if skin is exposed to chemicals.

    Caution:

    Do not allow the bearings to spin. Turn them slowly by hand. Spinning the bearings may damage the race and the rollers.

  1. Mark or tag the bearings in order to ensure they are properly installed in the correct location.
  2. Clean all of the roller bearings, needle bearings, and ball bearings in a suitable solvent and air dry all the parts.
  3. Inspect the bearings and races for the following conditions:
  • Inspect the cage bearings for being bent or for having damaged cages.
  • Replace the bearings with any of the above conditions.
  • Replace mated bearing parts when only one part is damaged.
  • Inspect the thrust washers for scoring or wear.
  • Replace any faulty thrust washers.
  • Do not file surfaces which have been hardened and precision ground.
  • Rear Wiper/Washer System Description and Operation
    The rear window wiper motor is located inside the hatchback door and is directly connected to the rear window wiper. Ignition voltage is supplied to the rear wiper motor through the wiper switch. ...

    Windshield Washer Solvent Container Filler Tube Replacement
    Windshield Washer Solvent Container Filler Tube Replacement Callout Component Name Preliminary Procedure Open and support the hood ...

    Other materials:

    Detecting the Vehicle Ahead
    The green vehicle ahead indicator will appear when a vehicle is detected ahead. Whenever this indicator does not appear, FCA will not respond. The indicator may disappear on curves, highway exit ramps, or hills, or due to poor visibility. The FCA system will not detect another vehicle ahead ...

    Headlamps, Front Turn Signal and Parking Lamps
    Passenger Side Shown, Driver Side Similar High-Beam Headlamp Low-Beam Headlamp Parking/Turn Signal Lamps High-Beam Headlamp/Low-Beam Headlamp Open the hood. See Hood. For the driver side bulb, remove the windshield washer bottle filler neck by turning it one-quarter ...

    Battery Inspection/Test
    Diagnostic Instructions Perform the Diagnostic System Check - Vehicle prior to using this diagnostic procedure. Review Strategy Based Diagnosis for an overview of the diagnostic approach. Diagnostic Procedure Instructions provides an overview of each diagnostic catego ...

    В© 2014-2024 Copyright www.csmans.com
     
    0.0058