Chevrolet Sonic Repair Manual: Timing Belt Lower Front Cover Installation
Caution:
Refer to Fastener Caution.
Install the timing belt cover (1) and tighten the 4 timing belt lower front cover bolts (2) to 6 Y (53 lb in)
.
Timing Belt Installation
Special Tools
EN-6333 Locking Pin
EN-6340 Locking Tool
For equivalent regional tools, refer to Special Tools.
Note: The timing belt drive gear and oil pump housing must align.
...
Timing Belt Lower Front Cover Removal
Remove the 4 timing belt lower front cover bolts (2).
Remove the timing belt lower front cover (1).
...
Other materials:
When to Add Engine Oil
1.8L Shown, 1.4L Similar
If the oil is below the minimum mark on the dipstick, add 1 L (1 qt) of the recommended
oil and then recheck the level. See “Selecting the Right Engine Oil” in this section
for an explanation of what kind of oil to use. For engine oil crankcase capacity,
see Cap ...
Throttle Body Inspection and Cleaning
Note: Over extended time and mileage, deposits may accumulate on the
back of the throttle valve plate. The source of the deposit is exhaust gas.
Typically these deposits pose no problem. Occasionally the deposit may accumulate
to a point where perceived pedal effort or throttle valve mov ...
Manual Transmission Shift Lever Cable Adjustment
Special Tools
DT-527-A Adjuster or 5mm drill bit
For equivalent regional tools, refer to Special Tools.
Note: Not using the specified tools may lead to shift system mis-adjustment.
Remove the floor console. Refer to
Front Floor Console Replacement.
Lift upward an ...
0.0065