Chevrolet Sonic Repair Manual: Valve Lifter Replacement

Chevrolet Sonic Repair Manual / Powertrain / Engine / General / Valve Lifter Replacement

Special Tools

EN-845 Suction Device

For equivalent regional tools, refer to Special Tools.

Removal Procedure

Remove the camshaft. Refer to Camshaft Replacement.

Note:

Mark the assignments.

Remove the valve lifter (1) use the EN-845 suction device .

Installation Procedure

Note:

Observe the correct assignment.

Note:

Coat the sliding surfaces with NEW engine oil.

Install the valve lifter (1) use the EN-845 suction device .
Install the camshaft. Refer to Camshaft Replacement.

Valve Lifter Removal

Special Tools EN-845 Suction Device For equivalent regional tools, refer to Special Tools. Note: Mark the locations. Remove the 16 valve lifter (1) use the EN-845 suction ...

Vehicle, Engine and Transmission ID and VIN Location, Derivative and Usage

The vehicle identification number (VIN) plate is the legal identifier of the vehicle. The VIN plate is located on the upper left corner of the instrument panel (I/P) and can be seen through th ...

Other materials:

Rear Wheel Speed Sensor Replacement
Removal Procedure Warning: Refer to Brake Dust Warning. Raise and support the vehicle. Refer to Lifting and Jacking the Vehicle. Remove the tire and wheel assembly. Refer to Tire and Wheel Removal and Installation. Remove the rear wheel speed sensor ...

Power Steering Pump Belt Installation
Special Tools EN-50098 Belt Installer For equivalent regional tools, refer to Special Tools. Install EN-50098 installer (2) and a NEW power steering pump belt (1) to water pump pulley and power steering pump pulley. Turn the engine slowly clockwise at the crankshaft ...

New Vehicle Break-In
Notice: The vehicle does not need an elaborate break-in. But it will perform better in the long run if you follow these guidelines: Do not drive at any one constant speed, fast or slow, for the first 805 km (500 mi). Do not make full-throttle starts. Avoid downshifting t ...

0.0058