Chevrolet Sonic manuals

Chevrolet Sonic Repair Manual: Secondary Air Injection Pump Replacement

Chevrolet Sonic Repair Manual / Powertrain / Engine / Emissions / Air Injection / Secondary Air Injection Pump Replacement



Secondary Air Injection Pump Replacement

Callout

Component Name

1

Secondary Air Injection Pump Inlet Pipe

Note:

Squeeze the retainer on opposite sides to release.

2

Secondary Air Injection Pump Outlet Pipe

Note:

Squeeze the retainer on opposite sides to release.

3

Secondary Air Injection Pump Electrical Connector

4

Secondary Air Injection Pump Bolt

Caution:

Refer to Fastener Caution.

Tighten


22 Y (16 lb ft)

5

Secondary Air Injection Pump Nut

Tighten


22 Y (16 lb ft)

6

Secondary Air Injection Pump

Secondary Air Injection Pump Removal
Disconnect the secondary air injection pump pipe (3). Refer to Plastic Collar Quick Connect Fitting Service. Remove the secondary air injection pump nut (2) and the 2  ...

Secondary Air Injection System Description
The Secondary Air Injection System aids in the reduction of hydrocarbon exhaust emissions during a cold start. This occurs when the start-up engine coolant temperature (ECT) is between −10 t ...

Other materials:

Quarter Outer Panel Pressure Relief Valve Replacement
Quarter Outer Panel Pressure Relief Valve Replacement Callout Component Name Preliminary Procedure Remove the rear bumper fascia. Refer to Rear Bumper Fascia Replacement 1 Quarter Outer Panel Pre ...

Seat Belt Service Precautions
Note: If the vehicle has been in a collision, refer to Repairs and Inspections Required After a Collision for additional information. Do not bleach or dye the seat belt webbing. Use only the following items in order to clean the seat belt webbing: A mild soap and water ...

Front Wheel Drive Shaft Seal Replacement - Left Side
Special Tools DT-446 Installer Drift DT-7004 Slide Hammer DT-23129 Universal Seal Remover For equivalent regional tools, refer to Special Tools. Removal Procedure Raise and support the vehicle. Refer to Lifting and Jacking the Vehicle. Remove the front suspension s ...

В© 2014-2022 Copyright www.csmans.com
 
0.0064