Chevrolet Sonic manuals

Chevrolet Sonic Repair Manual: Rear Side Door Window Weatherstrip Replacement (Sedan)

Chevrolet Sonic Repair Manual / Body / Glass & Windows / General / Rear Side Door Window Weatherstrip Replacement (Sedan)



Rear Side Door Window Weatherstrip Replacement

Callout

Component Name

Preliminary Procedures

  1. The rear door side window weatherstrip and window is serviced as one assembly. Refer to Rear Side Door Stationary Window Replacement.
  2. Remove the rear side door window . Refer to Rear Side Door Window Replacement.

1

Rear Side Door Window Weatherstrip Lower Bolt

Caution:

Refer to Fastener Caution.

Procedure

Remove the rear side door water deflector.

Tighten


9?€‰Y (80?€‰lb?€‰in)

2

Rear Side Door Window Weatherstrip Upper Screw

Procedure

  1. Pull the door weatherstrip out of the upper retainer to expose the screw.
  2. Remove the weatherstrip from the front and rear lower guides.
  3. Grasp both upper corners, pull downward releasing the weatherstrip from the door frame.
Tighten


3?€‰Y (27?€‰lb?€‰in)

3

Rear Side Door Window Weatherstrip

Procedure

  1. Insert the weatherstrip downward in the guide until fully seated.
  2. Carefully move the regulator upward for short slow intervals, while ensuring that the window remains in the guides.
  3. Inspect the door window for proper operation before installing the door trim panel.
Rear Side Door Window Weatherstrip Replacement (Hatchback)
Rear Side Door Window Weatherstrip Replacement Callout Component Name Preliminary Procedure Remove the rear side door window . ...

Rear Window Defogger Description and Operation
Rear Window Defogger System Components The rear window defogger system consist of the following components: The HVAC control module The body control module (BCM) The rear defogger ...

Other materials:

Brake Fluid
The brake/clutch master cylinder reservoir is filled with DOT 3 brake fluid as indicated on the reservoir cap. See Engine Compartment Overview  for the location of the reservoir. There are only two reasons why the fluid level in the reservoir might go down: The fluid level goes down ...

Hood Rear Seal Replacement
Hood Rear Seal Replacement Callout Component Name 1 Hood Rear Seal Procedure Clean the area where the seal will be mounted. Use a suitable solvent with a mixture of 50?€‰percent isopropyl alcohol and 50?â ...

Special Tools
Illustration Tool Number/Description EL 38758 EL 50074 J 38758 Parasitic Draw Test Switch EL 50313 EL 42000 EL 50076 J 42000 ...

© 2014-2025 Copyright www.csmans.com
 
0.0065