Chevrolet Sonic Repair Manual: General
- Air Cleaner Assembly Replacement
- Air Cleaner Element Replacement
- Air Cleaner Inlet Duct Replacement
- Air Cleaner Outlet Duct Replacement
- Air Intake System Description
- Camshaft Actuator System Description
- Camshaft Position Actuator Solenoid Valve Replacement
- Charge Air Bypass Regulator Solenoid Valve Replacement
- Charge Air Cooler Inlet Air Hose Replacement
- Charge Air Cooler Outlet Air Hose Replacement
- Charge Air Cooler Replacement
- Crankshaft Position System Variation Learn
- Electronic Ignition System Description
- Engine Oil Pressure Indicator Switch Replacement
- Evaporative Emission Canister Purge Solenoid Valve Replacement
- Evaporative Emission Canister Replacement
- Evaporative Emission Canister Replacement (Steel Tank)
- Evaporative Emission Canister Vent Solenoid Valve Replacement
- Evaporative Emission Control System Description
- Evaporative Emission System Hose/Pipe Replacement
- Fuel Feed Pipe Replacement
- Fuel Injection Fuel Rail Assembly Replacement
- Fuel Injector Replacement
- Fuel Pressure Measurement
- Fuel Pressure Relief
- Fuel Pump Flow Control Module Replacement
- Fuel System Cleaning
- Fuel System Description
- Fuel Tank Draining
- Fuel Tank Filler Pipe Replacement
- Fuel Tank Filler Pipe Replacement (Steel Tank)
- Fuel Tank Fuel Pump Module Replacement
- Fuel Tank Fuel Pump Module Replacement (Steel Tank)
- Fuel Tank Replacement
- Ignition Coil Replacement
- Inspection/Maintenance (I/M) System DTC Table
- Inspection/Maintenance (I/M) System DTC Table (LUW)
- Inspection/Maintenance (I/M) System DTC Table (LWE)
- Inspection/Maintenance Complete System Set Procedure
- Inspection/Maintenance System Check
- Plastic Collar Quick Connect Fitting Service
- Secondary Air Injection Check Valve Replacement
- Secondary Air Injection Pump Air Cleaner Pipe Replacement
- Secondary Air Injection Pump Pipe Replacement
- Secondary Air Injection Pump Replacement
- Secondary Air Injection System Description
- Spark Plug Inspection
- Spark Plug Replacement
- Special Tools
- Special Tools (Diagnostic Tools)
- Turbocharger System Description
- Turbocharger Wastegate Regulator Solenoid Valve Replacement
Engine Control
...
Air Cleaner Assembly Replacement
Air Cleaner Assembly Replacement
Callout
Component Name
1
Air Cleaner Outlet Duct Clamp.
Procedure
Loosen clamp a ...
Other materials:
Hood Hinge Replacement
Hood Hinge Replacement
Callout
Component Name
Preliminary Procedures
Remove the hood. Refer to Hood Replacement.
Remove the front fender. Refer to Front Fender Replacement.
1
Hood Hinge Bolt (Q ...
Scrub Radius Description
Ideally, the scrub radius is as small as possible. Normally, the SAI angle and
the centerline of the tire and the wheel intersect below the road surface, causing
a positive scrub radius. With struts, the SAI angle is much larger than the long
arm/short arm type of suspension. This allows the S ...
Starter Installation
Install the starter (4).
Install the lower starter bolt stud (3) and if equipped the washer.
Install the upper starter bolt (2) and if equipped the washer (1).
Caution: Refer to Fastener Caution.
Tighten the starter bolt and starter bolt stud to 25 ...
0.0069